Aqua Softner Descaler-Puroxi

Descaling and Scale Prevention

The electromagnetic wave action creates a large number of suspension and condensation in the water. When the water is heated, or the pressure (psi) decreases, the calcium (Ca) and magnesium (Mg) plasma in the hard water is absorbed. This action is called crystal nucleation and creates a process that occurs in forming a crystal from the solution. This process begins with another form of calcium carbonate that has a very distinct characteristic to calcite. When the calcium carbonate precipitates as aragonite, it forms a non-adhering harmless insoluble crystal that is either consumed or carried through the system to the drain. This process prevents scaling by not adhering to the surface of plumbing, heaters, industrial coolers, or other equipment. The existing scale will gradually dissolve in the water.

Aqua softner descaler test

Scale Analysis of Heat-exchange efficiency

Condenser Scale  Pyro conductivity 
Calcium Carbonate  2.93 
Microorganism Membrane  0.63 
calcium phosphate  2.60 
phosphate  2.16 
magnetic iron oxide  2.88 
Scale Thickness Heat-exchange rate Heat loss percentage Electricity Consumption percentage
0 92.77 0 0%
0.3mm 73.68 21% 10%
0.6mm 61.12 34% 20%
0.9mm 52.20 44% 31%
1.2mm 45.60 56% 42%
1.6mm 39.52 57% 53%

The Puroxi Aqua-Softener system effectively deals with scale problems physically and with no chemicals needed.

Blocked plumbing + scale and corrosion is equal to low energy exchange, low production output, increased energy consumptions and potential hazards.

Eco-environmental scale removal solutions

The most common solution in the past has been the water softener.

If you install a softener, you have to buy salt. Salt can be expensive over time and is not suitable for the environment.

We have plumbing diameters between 1/8" -80" (4-2000mm) – Dust-proof IP65 level shell to resist any challenging installation process.

There is no need to cut plumbing

Easy installation in all types of plumbing: iron, copper, stainless steel, galvanized iron, PVC, pe-x, and any composite material plumbing.

aqua softener descaler

One of the most remarkable things about Aqua-Softener is its sizing.

The plumbing size options are as follows.

1.5" plumbing

2" – 2.5" plumbing

3" – 4" plumbing

5" plumbing

6" plumbing

10" plumbing

12" plumbing

14" plumbing

16" plumbing

18" plumbing


Carmangay Colony Alberta was established in 1975. Our 180,000 BTU boiler in the dairy barn has been in service for 6 years, we had to cleanout the boiler every 4 months by manually removing and washing out the scale. The boiler normally would last about 8 years. We were skaptical, but decided to do a trial with the Aqua-softener. 2 months after the Aqua-softener was installed before the boiler the scale started to loosen up and fell to the bottom of the boiler. In 6 months the heating pipes were all clean and it left about 4" of debris on the bottom and then we removed the debris. After this was cleaned out we had to turn the heat down from 170 F to 150 F as the pressure relief was going off. We estimate a 13% savings in heating cost. Before the Aqua-softener was installed we had issues with bacteria in the milk at 150 F and so the boiler was turned up to 170 F. Now with the Aqua-softener installed and the temperature set back at 150 F the bacteria count has not gone back up. Our individual bacteria count (IBC) levels have never been lower than 14,000 and sometimes up to 20,000, but now with the Aqua-Softener they are at 6,000. The cleaning chemicals seem to work better. We are working on upgrading our main water treatment system in our pumphouse and plan to install an Aqua-softener there too. My name is Joey Wurz.
boy icon